Product ID:26307 GRAY SEMIGLOSS FAST AIR DRY ENAMEL
MSDS Date:09/15/1993
FSC:8010
NIIN:00-965-8552
MSDS Number: BPFGF

RANDOLPH PRODUCTS CO

701 12TH STREET
CARLSTADT, NJ 07072-0830
US

Emergency Phone: 201-438-3700

Info Phone: 201-438-3700

Preparer: SU

Cage: 77672

RANDOLPH PRODUCTS CO

830 CARLSTADT, NJ 07072-0830 US

Telephone: 201-438-3700

Cage: 77672

SYNTHETIC RESIN SOLUTION

Fraction By Weight: 15%

ACGIH TLV: 100 PPM

MEDIUM OIL ALKYD RESIN SOLUTION

Fraction By Weight: 10.0%

NAPHTHA, LIGHT AROMATIC

CAS: 64742-95-6

Fraction By Weight: 5.0%

ALIPHATIC NAPHTHA [STODDARD SOLVENT]

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 10.0%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM; 9394

XYLENES (O-,M-,P- ISOMERS) (SARA III)

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 25.0%

OSHA PEL 100 PPM

ACGIH TLV: 100 PPM/150STEL;9394

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: CONTACT MAY CAUSE SKIN
IRRITATION. INHALATION OF HIGH CONCENTRATIONS MAY CAUSE CNS
EFFECTS, MAY BE FATAL. ASPIRATION DURING SWALLOWING OR VOMITING MAY
CAUSE CHEMICAL PNEUMONIA. CHRONIC: PROLONG ED OR REPEATED EXPOSURE
MAY CAUSE DRYING, CRACKING AND IRRITATION OF SKIN.
Explanation of Carcinogenicity:NO INGREDIENTS OF A CONCENTRATION OF
0.1% OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALATION: HEADACHES, DIZZINESS, ANESTHETIC,
DEATH. SKIN: RASH, SCALING, BLISTERING.
Medical Cond Aggravated by Exposure:PRE-EXISTING SENSITIVITY TO
SOLVENTS CAN CAUSE A HIGHTENED REACTION TO EXPOSURE TO THIS
PRODUCT.CONTACT LENS WEARERS SHOULD CONSULT PROVIDER BEFORE
HANDLING.CONSULT DOCTOR IF THERE IS ANY EYE CONTACT.

First Aid:SKIN: FLUSH WITH WATER. INHALATION: REMOVE TO FRESH AIR.
RESTORE BREATHING. GET MEDICAL ATTENTION. EYE: IMMEDIATELY FLUSH
WITH WATER FOR 15 MINUTES. GET MEDICAL ATTENTION. INGESTION: GET
IMMEDIATE MED ICAL ATTENTION. DO NOT INDUCE VOMITING.KEEP PERSON
WARM & QUIET.

Flash Point Method:SCC
Flash Point:=26.1C, 79.F
Lower Limits:0.9
Upper Limits:7.0
Extinguishing Media:USE CARBON DIOXIDE, FOAM, OR DRY CHEMICAL. WATER
STREAM WILL SPREAD FIRE. DO NOT USE WATER HOSE STREAM.
Fire Fighting Procedures:WEAR FULL FIRE FIGHTING PROTECTIVE EQUIPMENT
AND A FULL FACED SELF CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS WITH WATER SPRAY.
Unusual Fire/Explosion Hazard:KEEP CONTAINERS TIGHTLY CLOSED,AVOID
EXTREME HEAT.CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME
HEAT.

Spill Release Procedures:ELIMINATE ALL IGNITION SOURCES. PROVIDE
MAXIMUM AVAILABLE VENTILATION. WEAR PROTECTIVE CLOTHING. STOP LEAK
IF NO RISK. ABSORB ON AN INERT MATERIAL AND REMOVE WITH
NON-SPARKING TOOLS. DISCARD INTO SEAL ED CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:DRUMS SHOULD BE GROUNDED & BONDED WHEN
BEING EMPTIED. DLA-HMIS: STORE IN A COOL, DRY PLACE AWAY FROM
SOURCES OF IGNITION AND INCOMPATIBLE MATERIALS.
Other Precautions:PROVIDE RESPIRATORY PROTECTION AGAINST FUMES
GENERATED DURING BURING.

Respiratory Protection:DLA-HMIS: IF ENGINEERING CONTROLS FAIL OR
NON-ROUTINE USE OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED
RESPIRATOR OR SUPPLIED AIR RESPIRATOR OR SCBA, AS REQUIRED. USE IAW
29 CFR 1910.134 AND MANUFACTU RER'S RECOMMENDATIONS.
Ventilation:SUFFICIENT VENTILATION, IN VOLUME & PATTERN, MUST BE
PROVIDED TO KEEP AIR CONTAMINATION BELOW TLV.
Protective Gloves:VITON, NITRILE RUBBER, OR NEOPRENE
Eye Protection:CHEMICAL SPLASH GOGGLES OR FACESHIELD
Other Protective Equipment:USE PROTETCIVE SKIN CREAMS WHERE SKIN
CONTACT LIKELY. DLA-HMIS: EYE WASH STATION & SAFETY SHOWER.
Work Hygienic Practices:USE NORMAL HYGIENE PRACTICES DURING AND AFTER
HANDLING THIS MATERIAL.
Supplemental Safety and Health
DRUMS SHOULD BE GROUNDED WHEN BEING EMPTIED. USE PROPER PERSONAL
PROTECTIVE AND RESPIRATORY PROTECTION AGAINST VAPORR AND MIST.

HCC:F3
Boiling Pt:>137.2C, 279.F
Vapor Density:>1.0
Spec Gravity:1.3
Evaporation Rate & Reference:<1 (ETHER=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:THIN GREY LIQUID, TYPICAL SOLVENT
Percent Volatiles by Volume:35.1

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, ACIDS AND ALKALIES.
Stability Condition to Avoid:AVOID EXPOSURE TO SOURCES OF IGNITION,
STRONG OXIDIZING AGENTS, STRONG ALKALIS, AND STRONG MINERAL ACIDS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION RELEASES CARBON
MONOXIDE AND/OR CARBON DIOXIDE.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.